Frigidaire DH300MY5 Bedienungsanleitung

DehumidifierSERVICE MANUALMODELS: DH300EY5/DH305Y5/DH300MY5LD40Y5/DH400MY5DH404EY5/DH400EY5/LD40EY5DH504ELY5/LD50ELY5LD65ELY5http://biz.LGservice.comC

—10—• MODEL : DH400MY5/LD40Y5Q'TYPER SET11111111111RE-MARKSSSSSSSSSSSS1234567891011DESCRIPTIONPOWER CORD ASSEMBLYSWITCH, ROCKERMOTOR ASSEMBLYCAPA

—11—• MODEL :DH404EY5/DH400EY5/LD40EY5Q'TYPER SET111111111RE-MARKSSSSSSSSSS123456789DESCRIPTIONPOWER CORD ASSEMBLYMOTOR ASSEMBLYCAPACITORCOMPRESS

—12—• MODEL : DH504ELY5/LD50ELY5/LD65ELY5Q'TYPER SET1111111111RE-MARKSSSSSSSSSSS12345678910DESCRIPTIONPOWER CORD ASSEMBLYMOTOR ASSEMBLYCAPACITORC

3.1 MECHANICAL PARTS3.1.1 BUCKET AND AIR FILTER1. Turn the Humidity Control off(Mechanical type) orpress the power button off. (Electronic type)2. Dis

3.2 CONTROL PARTS 3.2.1 POWER CORD ASSEMBLY1. After opening the control box, remove the screwthat holds the ground wire. (See Figure 15)2. Disconnect

—15—3.2.6 COIL ASSEMBLY, SOLENOID(DH504ELY5, LD50ELY5, LD65ELY5)1. Disconnect the housing of the COIL ASSEMBLY,SOLENOID from the PCB(PWB) ASSEMBLY,MAI

3.2.8 FAN AND MOTOR1. Turn the nut left and full out the Fan by handscarefully.2. Remove 2 screws that fasten Heat Exchange.3. Lift the H/E and open t

—17—3.3 REFRIGERATING CYCLE3.3.1 CONDENSER, EVAPORATOR ANDCAPILLARY TUBE1. Remove the insulation on the Heater/Evaporator(H/E) assembly2. Pierce the p

—18—1. When replacing a refrigeration component, be sureto discharge the refrigerant system by using arefrigerant recovery system.2. After discharging

—19—Equipment needed: Vacuum pump, charging cylinder, manifold gauge, brazing equipment. pinch-off tool capableof making a vapor-proof seal, leak dete

—2—1. PREFACE1.1 SAFETY PRECAUTIONS...

CONDITION1. Dehumidifier does not start. (Bothcompressor and fan motor do notoperate.)2. Motor runs but compressor does notrun.3. Does not defrost con

—21—CONDITION5. Noisy operating6. Water drips7. Compressor cycles on overloadprotector. (OLP)CAUSEFanLoose foreign material inside the housing.Tube hi

—22—5. EXPLODED VIEWS• MODEL: DH305Y5/DH300MY535421055403013140034960014998016501034681135901226411014839114441075214015230243650024995026601013041023

—23—• MODEL: DH300EY5354210554030131400349600149980165010346811359012264110148391144410752140436500249950266010130410435300330870135312W0CZZ-2268711-2

—24—• MODEL: DH400MY5/LD40Y5W0CZZ-2165010268711-226411024995035211355211155014056750255416035421055403013140034960014998034681135901214839114441075214

—25—• MODEL: DH404EY5/DH400EY5/LD40EY5W0CZZ-2165010268711-22641102499503521135521115501405675025541603542105540301353121314003496001499803468113590121

—26—• MODEL: DH504ELY5/LD50ELY5W0CZZ-2165010268711-226411024995035211A35211355220456750255416055014035421055403013531213140034960014998034681135901214

—27—• MODEL: LD65ELY5W0CZZ-2165010268711-226411024995035211A552204352113567502554160550140354210135312554030131400349600149980346811359012148391144410

—28—6. REPLACEMENT PARTS LIST• MODEL: DH305Y5/DH300MY5130410 BASE ASSEMBLY 3041A10042A131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A1028

—23—• MODEL: DH300EY5130410 BASE ASSEMBLY 3041A10042A131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A10254F330870 DRAIN PAN ASSEMBLY 3087A

—3—1. PREFACEThis Service Manual provides various service information, including the mechanical and electrical parts.This dehumidifier was manufacture

—30—• MODEL: DH400MY5/LD40Y5130410 BASE ASSEMBLY 3041A10042B131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A10285E / 3531A20285B "B:L

—31—• MODEL: DH404E Y5/DH400EY5/LD40EY5130410 BASE ASSEMBLY 3041A10042B131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A10254A/E "A:Go

—32—• MODEL: DH504ELY5/LD50ELY5130410 BASE ASSEMBLY 3041A10042A131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A10254A/E "A:Goldstar/E

—33—• MODEL: LD65ELY5130410 BASE ASSEMBLY 3041A10042A131400 CABINET 3090A10042A135312 FRONT GRILLE,ASSEMBLY 3531A10254E330870 DRAIN PAN ASSEMBLY 3087A

P/No : 3828A31001January, 2005Printed in China

—4—1.4 SPECIFICATIONS1.3 MODEL NAMESMODEL NAMECAPACITY (Pints/24hrs) 30 40 50 65MECHANICAL TYPEELECTRONIC TYPECONTROLPANELDH3

—5—123456789OffMaxHighLowFan SpeedHumidity ControlAutoShut-OffConstantly On.FANSPEEDTIMERHighLow4hr. On/Off2hr. On/OffHUMIDITYCONTROLBUCKETFULLPOWERAU

—6—1.6.1 HOW DOES THE DEHUMIDIFIER WORK?Moist, humid air is drawn over a cold refrigerateddehumidifying coil. Moisture in the air condenses on thiscoi

—7—1.6.5 HUMIDITY CONTROLLER1.6.5.1 Mechanical TypeThe humidity control can be set anywhere between Off andMax for normal operation.If you need more d

—8—2. CIRCUIT DIAGRAM• MODEL : DH305Y5, DH300MY5Q'TYPER SET11111111111RE-MARKSSSSSSSSSSSS1234567891011DESCRIPTIONPOWER CORD ASSEMBLYSWITCH, ROCKE

—9—• MODEL : DH300EY5S: SERVICE PARTS A: ALTERNATE PARTS N: NOT SERVICE PARTSQ'TYPER SET111111111RE-MARKSSSSSSSSSS123456789DESCRIPT